Analysis of The Optical Properties of The Synthesis of Fe3o4/Pani Nanocomposites with The Sol-Gel Method using Spin Coating

Nadya Aztifa - Department of Physics, Universitas Negeri Padang, Jl. Prof. Dr. Hamka Air Tawar Padang 25131, Indonesia
Yenni Darvina - Department of Physics, Universitas Negeri Padang, Jl. Prof. Dr. Hamka Air Tawar Padang 25131, Indonesia
- Ramli - Department of Physics, Universitas Negeri Padang, Jl. Prof. Dr. Hamka Air Tawar Padang 25131, Indonesia
Rahmat Hidayat - Department of Physics, Universitas Negeri Padang, Jl. Prof. Dr. Hamka Air Tawar Padang 25131, Indonesia

Abstract


Research has been carried out on the analysis of the optical properties of Fe3O4/PANi nanocomposites synthesized by the sol-gel method using spin coating. The purpose of this study was to determine the crystal structure, crystal size, surface morphology, and optical properties of the Fe3O4/PANi nanocomposite thin films. One of the applications of optical properties is that it can be used as a semiconductor. In this study, the primary material used was iron sand obtained from Oyster Beach, Padang Pariaman Regency, West Sumatra. Iron sand contains a magnetite (Fe3O4) phase, which has the highest magnetic properties, and the polymer used is a type of polyaniline polymer (PANi) which has good chemical stability. Fe3O4 acts as a filler, while PANi acts as a matrix. In this study, five variations of the composition of Fe3O4 in PANi were used, namely 30%, 40%, 50%, 60%, and 70%. For the method used, namely the sol-gel method and sample testing using XRD, SEM, and UV-Vis Spectrophotometer characterization tools. The results of the XRD characterization showed that each addition of PANi into Fe3O4 did not affect the resulting crystal structure and had a crystal size below 100 nm. SEM testing revealed the presence of agglomeration and particle size at variations of 30%, 40%, 50%, 60%, and 70% were 27 µm, 53 µm, 61 µm, 84 µm, and 46 µm respectively. And the results of the UV-Vis Spectrophotometer test obtained energy gap values for variations in the composition of Fe3O4 in PANi, namely 30%, 40%, 50%, 60%, and 70%, respectively, namely 2.51 eV, 2.39 eV, 2.18 eV, 2.35 eV, and 2.30 eV. Based on the research results, it can be proven that the Fe3O4/PANi nanocomposite thin layer is a semiconductor material because it is in the range of 0-3 eV.

Full Text:

PDF

References


N. Yulfriska, Ramli, dan Y. Darvina. (2017). “Analisis Sifat Optik Dari Lapisan Tipis Fe3O4 Yang Dipreparasi Dari Pasir Besi Pantai Tiram Kabupaten Padang Pariaman Sumatera Barat Dengan Metoda Sol-Gel Spin Coating”.

D. Rianto, N. Yulfriska, F. Murti, H. Hidayati, and R. Ramli. “Analysis of Crystal Structure of Fe3O4 Thin Films Based on Iron Sand Growth by Spin Coating Method”. IOP Conf. Ser. Mater. Sci. Eng., Vol. 335, No. 1, 2018, doi: 10.1088/1757-899X/335/1/012012.

F. Rudyah Putri Nurzam, R. dan Ratnawulan Jurusan Fisika, F. Matematika dan Ilmu Pengetahuan Alam, U. Negeri Padang, dan J. Hamka Air Tawar. “Pengaruh Komposisi CoFe2O4 Terhadap Sifat Listrik Nanokomposit CoFe2O4/PANi Yang Disintesis Dengan Metoda Sol-Gel. ” Pillar Phys., Vol. 12, No. 1, pp. 38–45, 2019.

R. Ramli, R. Jonuarti, and A. Hartono. “Analisis Struktur Nano Dari Lapisan Tipis Cobalt Ferrite Yang Dipreparasi Dengan Metode Sputtering”. EKSAKTA Berk. Ilm. Bid. MIPA, Vol. 18, No. 01, pp. 46–53, 2017, doi: 10.24036/eksakta/vol18-iss01/16.

J. Nanosains. “Fabrikasi Material Nanokomposit Superkuat, Ringan dan Transparan Menggunakan Metode Simple Mixing”. Vol. 1, No. 1, pp. 14–21, 2008.

H. O. Yuzria and Astuti. “Sifat Listrik dan Optik Nanokomposit Epoxy Resin-TiO2”. Fis. Unand, Vol. 2, No. 2, pp. 135–139, 2013.

R. B. Permana, T. Saragi, M. Saputri, L. Safriani, I. Rahayu. “Sintesis Nanopartikel ZnO dengan Metode Kopresipitasi”. J. Tek. POMITS, Vol. 07, No. 02, pp. 1–7, 2009.

E. L. Y. Nasution dan Astuti. “Sintesis Nanokomposit PANi/Fe3O4 sebagai Penyerap Magnetik pada Gelombang Mikro”. J. Fis. Unand, Vol. 1, No. 1, pp. 37–44, 2012.

D. S. Dhawale, A. Vinu, and C. D. Lokhande. “Stable Nanostructured Polyaniline Electrode for Supercapacitor Application”. Electrochim. Acta, Vol. 56, No. 25, pp. 9482–9487, 2011, doi: 10.1016/j.electacta.2011.08.042.

T. Liu et al. “Supporting Information Polyaniline and Polypyrrole Pseudocapacitor Electrodes with Excellent Cycling Stability”. Adv. Mater., pp. 1–11.

Helmita, Ramli, dan Hidayati. “Pengaruh Variasi Komposisi Pada Sifat Magnet Dari Nanokomposit NiFe2O4/PANi Yang Disintesis Dengan Metode Sol-Gel Spin Coating”. Pillar Phys., Vol. 12, No. 1, pp. 46–53, 2019.

Hidayat, A. S., Rokhmat, M., & Qurthobi, A. (2014). Pengaruh Suhu dan Kecepatan Putar Spin Coating Terhadap Kinerja Sel Surya Organik Berbahan Dasar TiO2. e-Proceeding Eng., Vol. 1, No. 1, pp. 497–510, 2014.

M. M. Y. Missa, R. K. Pingak, H. I. Sutaji, J. Fisika, F. Sains, dan J. Adisucipto. “Penentuan Celah Energi Optik Ekstrak Daun Alpukat (Persea Americana Mill) Asal Desa Oinlasi Menggunakan Metode Tauc Plot”. Vol. 3, No. 1, pp. 86–90, 2018.

R. Sarkar, C. S. Tiwary, P. Ã. Kumbhakar, S. Basu, and A. K. Mitra, “Yellow-Orange Light Emission from Mn2+-Doped ZnS Nanoparticles”. Vol. 40, pp. 3115–3120, 2008, doi: 10.1016/j.physe.2008.04.013.

H. El Ghandoor, H. M. Zidan, M. M. H. Khalil, and M. I. M. Ismail, “Synthesis and Some Physical Properties of Magnetite (Fe3O4) Nanoparticles”. Int. J. Electrochem. Sci., Vol. 7, No. 6, pp. 5734–5745, 2012.

C. O. Pani et al. “Analisis Sifat Magnetik Nanokomposit”. Vol. 12, No. 1, pp. 30–37, 2019.

M. Khairy and M. E. Gouda, “Electrical and Optical Properties of Nickel Ferrite/Polyaniline Nanocomposite,” J. Adv. Res., Vol. 6, No. 4, pp. 555–562, 2015, doi: 10.1016/j.jare.2014.01.009.

P. Simamora, M. Manullang, J. Munthe, and J. Rajagukguk, “The Structural and Morphology Properties of Fe3O4/Ppy Nanocomposite”. J. Phys. Conf. Ser., Vol. 1120, No. 1, 2018, doi: 10.1088/1742-6596/1120/1/012063.

C. Umamah. “Studi Analisis Fasa dan Ukuran Kristal Spinel MgAl2O4 Dengan Metode Pencampuran Logam Terlarut Asam Klorida”. J. Pemikir. Penelit. Pendidik. dan Sains, Vol. 3, No. 6, pp. 128–139, 2015.

Septiana Kurniasari. “Indonesian Physical Review”. Indones. Phys. Rev., Vol. 2, No. 3, pp. 1–8, 2019.

Y. Mardani. “Akasia Dengan Tumbukan Bola Baja Diameter”. pp. 1–14, 2019.

J. Liman, B. Harsono, T. T. Rohman, U. Trimukti, E. Roharti, and A. A. D. Bahan, “Uji Sifat Optik Film Tipis Ba0.55Sr0.45TiO3 di Atas Substrat Corning Glass 7059,” Vol. XIX, No. November, pp. 45–48, 2013.

S. Gomathi, G. Sowmiya, G. Velraj, and S. Sakthikailassh, “Iaetsd Journal for Advanced Research in Applied Sciences Issn No : 2394-8442 an Optical and Electrical Conductivity Study of Conducting Polymer Blended With Nano Metal Oxide Composites Iaetsd Journal for Advanced Research in Applied Sciences Issn No : 239,” Vol. 5, No. 1, pp. 338–344.




DOI: http://dx.doi.org/10.24036/14332171074